Suzuki New CARRY 2019 Maintenance under Severe Driving Conditions User Manual

Suzuki Logo

Suzuki New CARRY 2019 Maintenance under Severe Driving Conditions User Manual

Maintenance Recommended under Severe Driving Conditions

Follow this schedule if your vehicle is mainly operated under one or more of the following conditions:

  1. When most trips are less than 6 km (4 miles).
  2. When most trips are less than 16 km (10 miles) and the outside temperature remains below freezing.
  3. Idling and/or low-speed operation in stop-and-go traffic.
  4. Operating in extremely cold weather and/or on salted roads.
  5. Operating in rough and/or muddy areas.
  6.  Operating in dusty areas.
  7. Repeated high-speed drive or high engine revolutions.
  8. Towing a trailer, if admitted.
  9. The schedule should also be followed if the vehicle is used for delivery service, police, taxi or other commercial applications.
Interval: This interval should be judged by odometer reading or months, whichever comes first. km (x1000) 7.5 15 22.5 30 37.5 45
miles (x1000) 4.5 9 13.5 18 22.5 27
months 6 12 18 24 30 36
ENGINE
*1-1. Engine accessory drive belt                    Tension check, *Adjustment, *Replacement I I I I R I
*1-2. Valve clearance I
1-3. Engine oil and engine oil filter R R R R R R
1-4. Engine coolant R
*1-5. Exhaust system (except catalyst) I
IGNITION
2-1. Spark plugs                                         Nickel plugs Replace every 10000 km (6000 miles) or 8 months.
FUEL
3-1. Air cleaner filter element*1 Inspect every 2500 km (1500 miles).
Replace every 30000 km (18000 miles) or 24 months.
*3-2. Fuel lines I
*3-3. Fuel filter Replace every 105000 km (63000 miles).
*3-4. Fuel tank I
EMISSION CONTROL SYSTEM
*4-1. PCV valve
*4-2. Fuel evaporative emission control system
Interval: This interval should be judged by odometer reading or months, whichever comes first. km (x1000) 52.5 60 67.5 75 82.5 90
miles (x1000) 31.5 36 40.5 45 49.5 54
months 42 48 54 60 66 72
ENGINE
*1-1. Engine accessory drive belt                    Tension check, *Adjustment, *Replacement I I I R I I
*1-2. Valve clearance I I
1-3. Engine oil and engine oil filter R R R R R R
1-4. Engine coolant R
*1-5. Exhaust system (except catalyst) I I
IGNITION
2-1. Spark plugs                                         Nickel plugs Replace every 10000 km (6000 miles) or 8 months..
FUEL
3-1. Air cleaner filter element*1 Inspect every 2500 km (1500 miles).
Replace every 30000 km (18000 miles) or 24 months.
*3-2. Fuel lines I I
*3-3. Fuel filter Replace every 105000 km (63000 miles).
*3-4. Fuel tank I
EMISSION CONTROL SYSTEM
*4-1. PCV valve I
*4-2. Fuel evaporative emission control system I
Interval: This interval should be judged by odometer reading or months, whichever comes first. km (x1000) 7.5 15 22.5 30 37.5 45
miles (x1000) 4.5 9 13.5 18 22.5 27
months 6 12 18 24 30 36
BRAKE
*5-1. Brake discs and pads (front) I I I I I I
Brake drums and shoes (rear) I I I I I I
*5-2. Brake hoses and pipes I I I
*5-3. Brake fluid I R I R I R
*5-4. Brake (Pedal and fluid level) I I I
5-5. Parking brake lever and cable I I I I I I
CHASSIS AND BODY
*6-1. Clutch pedal I I I
6-2. Tyres/Wheels I I I
*6-3. Wheel bearings I I I
*6-4. Propeller shafts I I I
*6-5. Suspension system I
*6-6. Steering system I
*6-7. Manual transmission oil                            Genuine “SUZUKI GEAR OIL 75W-90”

Other than “SUZUKI GEAR OIL 75W-90”

R

R

*6-8. Rear differential oil R R
6-9. All latches, hinges and locks I
 WARNING
The shock absorbers are filled with high pressure gas. Never attempt to disassemble them or throw them into a fire. Avoid storing them near a heater or heating device. When scrapping the absorber, the gas must be released from the absorber safely. Ask a SUZUKI dealer or a qualified workshop for assistance.
Interval: This interval should be judged by odometer reading or months, whichever comes first. km (x1000) 52.5 60 67.5 75 82.5 90
miles (x1000) 31.5 36 40.5 45 49.5 54
months 42 48 54 60 66 72
BRAKE
*5-1. Brake discs and pads (front) I I I I I I
Brake drums and shoes (rear) I I I I I I
*5-2. Brake hoses and pipes I I I
*5-3. Brake fluid I R I R I R
*5-4. Brake (Pedal and fluid level) I I I
5-5. Parking brake lever and cable I I I I I I
CHASSIS AND BODY
*6-1. Clutch pedal I I I
6-2. Tyres/Wheels I I I
*6-3. Wheel bearings I I I
*6-4. Propeller shafts I I I
*6-5. Suspension system I I
*6-6. Steering system I I
*6-7. Manual transmission oil                            Genuine “SUZUKI GEAR OIL 75W-90”

Other than “SUZUKI GEAR OIL 75W-90”

R

R

R

R

*6-8. Rear differential oil R
6-9. All latches, hinges, and locks I I

Reference Links

View Full User Guide : Suzuki New CARRY 2019 User Manual

Download Manuals: https://suzuki-aftersales.net/manuals

Leave a Reply

Your email address will not be published. Required fields are marked *