Airstream Travel Trailer International 2023 Electrical Diagrams User Manual
Electrical Diagrams
12-Volt Main Schematic
120-Volt/30- and 50-Amp Diagrams
The following electrical diagrams are representative of the National Electric Code (NEC) and the Canadian Standards Association (CSA). All circuits are NEC with the exception of CSA circuits as specified in each respective table.
23FB International (30 Amp)
25RB International (30 Amp)
25RB International (50 Amp)
25RB International (50 Amp) – CSA
25FB International (50 Amp)
25FB International (50 Amp) – CSA
27FB International (30 Amp)
25FB International (50 Amp) – CSA
27FB International (30 Amp)
25FB International (50 Amp) – CSA
27FB International (30 Amp)
25FB International (50 Amp) – CSA
27FB International (30 Amp)
Solar Panel Wiring
For your convenience Airstreams has installed a 3 port easy install box to the roof of the trailer, as well as, a plug for a portable solar panel at the front of the trailer near the battery box. The roof port now allows for easy install of an aftermarket solar panel. Simply plug the power cord from the solar panel into the 3 port box. A Cat 5-patch cord for a solar panel display, if supplied with the after market unit, runs from the battery buss bar to an area just behind the See level Monitor display. The best way to reach the Cat 5 cable is to remove the See level Monitor. The solar panel display can be mounted in the area near the See level Monitor panel by routing the proper hole size. The Cat 5 wire is then plugged into the solar display panel.
NOTE
The yellow wire must be fused with a 35-amp in-line fuse at the 12-volt positive. All wires are identified with labels at all locations.
The solar panel has a charge controller that should be mounted close to the battery buss bars, as the battery leads and Cat 5 wire are hooked into it to sense the actual battery charge. The following diagram depicts the way Airstream wires the solar system on factory-installed units and is the recommended wiring for use of the pre-wire system.
Fresh Water Layouts
23FB International
25RB International
25FB International
27FB International
28RB International
30RB International
FAQs and Answers
Electrical
1. What size generator is needed to operate my Airstream?
Answer: A 1,000-watt generator may be used to charge just the batteries. However, if you want to run appliances such as microwave or AC units, it is recommended to have at least 4,000 watts or more (This is for a 30 amp system). Many Airs reamers accomplish this using two portable generators running in parallel
2. What can I plug into the 1000-watt inverter outlets in my Airstream?
Answer: These plugs are designed for no more than 1000 watts of power and are intended for charging things such as laptops and phones, and TV usage. Plugging in items such as vacuums, hairdryers, etc., may harm the system.
3. I was told my Airstream is pre-wired for solar panels.
What does this mean?
Answer: Wiring has been installed throughout your unit for the solar package Airstream is currently using. For more information on solar packages, you may wish to contact your Airstream dealer.
4. What type of batteries are in my Airstream?
Answer: Batteries are installed by your Airstream dealer. For details specific to the battery your dealer installed, refer to the manufacturer’s information.
5. Do you recommend using a surge protector when plugged into shore power?
Answer: Your Airstream is breaker protected. However, with the use of more personal electronic devices and the number of RV users in parks, added protection is always a plus.
6. What is the battery disconnect switch function?
Answer: It is a switch that disengages or engages the 12-volt power supply from the house batteries to everything but the LPG detector. The switch is used to cut power when the trailer is not being used or put into storage to preserve battery charge.
7. My power jack is not operating.
Answer:
- Check for 12-volt power.
- Verify the 30 amp spade fuse, located inside the battery box, is not blown. Replace if necessary.
- Loosen and retighten the jack head to establish a ground-to-jack post.
The jack may be raised and lowered using the hand crank provided, and by following the instructions in this owner’s manual.
8. What does the power converter do in my trailer?
Answer: The converter takes 120-volt AC shore power and turns it into 12-volt DC to keep batteries charged and power 12-volt items in your trailer.
Plumbing
1. While parked at my site, do you recommend leaving my dump valves open?
Answer: You cannot leave your black water valve open. This would cause a buildup inside the tank. You need to keep this closed until you are full or ready to leave. (Remember, use your no-fuss flush.)
2. How do I use my black water tank flush?
Answer: First, empty your black water tank, then close your black water tank valve. Hook up your hose to the external hookup, run a couple minutes, and then open the valve. Do this a couple of times until clear.
3. Do I need a water regulator?
Answer: No, your Airstream is equipped with a built-in regulator rated for 50 psi.
4. How do I get fresh water into my trailer?
Answer: You can use the onboard fresh water tank and 12-volt pump for your water supply when boondocking, or hook to an external water source via garden hose to the exterior water inlet when parked at a campground.
5. What is the difference between a gray water tank and the black tank?
Answer: The gray water tank holds water from the shower and sinks drains. The black water tank holds sewer water from the toilet.
Audio-Video
1. My TV reception is poor. What can I check?
Answer: Verify your antenna booster is set to proper selection (On- for antenna and Off- for cable satellite). You should also make sure connections are tight on your TV.
Appliances
1. I am planning for a trip in my Airstream. How should I get the refrigerator cooled down?
Answer: Cooling time will vary with exterior temperatures and time of day. Start by pre-cooling your refrigerator at least 12 hours prior to loading your refrigerator. Always pre-cool food in your refrigerator or freezer to reduce cooling time. Don’t pack food too tightly in compartment as to prevent circulation around food items. Normal refrigerator operating temperatures are 34ºF to 40ºF.
2. The heat pump in my trailer doesn’t seem to be providing any heat; yesterday it worked great.
Answer: The heat pump is designed to knock the chill off your trailer. It functions when outside temperature is 45ºF or greater by removing heat from the outside air. Below 45ºF it will not provide heat.
3. My air conditioner freezes up. What is the problem?
Answer: In high humidity conditions, the AC manufacturer recommends you operate your AC (manual mode) on the high fan setting and all vents should be open to have maximum air flow over the coils; this helps reduce icing. Also, dirty air conditioner filters can restrict air flow and cause the AC to ice up.
Maintenance
1. Where can I find my trailer serial number?
Answer: A label is attached on the roadside sheet at the front side sheet seam. This label will also provide the inflation pressure of the tires and GVWR. The serial number of the trailer is also stamped on the street side of the A frame by the LPG tanks.
2. Awning suggestions:
Your Zip Dee awning is intended to provide shade. If you are leaving your trailer for long periods or in threatening weather, the awning should be retracted. Visit the Zip Dee website for more information and instructional videos.
3. Cleaning the exterior of my Airstream.
Suggestions:
Airstream recommends washing the trailer using a mild auto detergent safe for clear coated surfaces. Airstream recommends washing based on operating conditions and waxing a minimum of twice a year. Walbernize Super seal is a product that was designed specifically for Airstream and provides good wax protection.
4. Can I use a nylon cover for my Airstream?
Answer: Airstream does not recommend using any type of cover. The installation and movement of the cover in windy conditions could scratch the clearcoat.
5. What type of attachments can I install on the rear of my Airstream?
Answer: Airstream only recommends the installation of a Fiamma bike rack (Airstream part number 209397) on the rear of trailers. No other carriers are recommended.
6. My main door is hard to open, is this normal?
Answer: Your main door is designed differently than a flat surface door. The door is over-bent in order to apply more pressure at the top and bottom of the door for better sealing. Also, on uneven surfaces, the trailer can be in a slight twist that could affect closing. Make sure the trailer is as level as possible.
7. How do I clean my drapes and upholstery?
Answer: Drapes may be dry-cleaned. Upholstery may be spot-cleaned. We recommend dry cleaning as the best overall cleaning solution.
8. What is a rubber torsion axle?
Answer: Your trailer has Dexter rubber torsion axles. This type of axle has internal rubber cords that provide load-carrying capacity versus leaf spring-type axles. Reminder – never jack up the trailer using rubber torsion axle tubes!
9. My windows are sticking and don’t open easily; what is wrong?
Answer: Your windows have rubber seals around the edges which in extreme heat and dusty conditions can become sticky. You can help prevent this by regularly cleaning window seals with soapy water and applying a silicone product or Aerospace Protectant 303 to the seals. Clean edge of glass also.
10. The mattress in my Airstream is an odd shape, where can I buy sheets?
Answer: Airstream has a selection of sheets for your Airstream that can be purchased by calling (937) 596-6111 extension 7400 or 7418. You can also access our store website at www.airstreamsupplycompany.com.
Reference Links
View Full User Guide: Airstream Travel Trailer International 2023 User Manual
Download Manuals: https://www.airstream.com/owners/manuals/
Airstream Bolt 2023 Top Accessories
[amalinkspro_table id=”32452″ new-window=”on” nofollow=”on” addtocart=”off” /]
